STATE OF
INDIANA |
) |
SS: |
BEFORE THE
INDIANA DEPARTMENT OF |
||||
|
) |
|
|
||||
COUNTY OF
MARION |
) |
|
ENVIRONMENTAL
MANAGEMENT |
||||
|
|||||||
COMMISSIONER
OF THE DEPARTMENT |
) |
|
|||||
OF
ENVIRONMENTAL MANAGEMENT, |
|
) |
|
||||
|
|
) |
|
||||
Complainant, |
|
) |
|
||||
|
|
) |
|
||||
|
v. |
|
) |
Case No. 2019-26537-A |
|||
|
|
) |
|
||||
REA MAGNET
WIRE COMPANY, INC., |
|
) |
|
||||
|
|
) |
|
||||
Respondent. |
|
) |
|
||||
AGREED ORDER
Complainant and Respondent desire to
settle and compromise this action without hearing or adjudication of any issue
of fact or law, and consent to the entry of the following Findings of Fact and
Order. Pursuant to Indiana Code (“IC”) 13-30-3-3, entry into the terms of this
Agreed Order does not constitute an admission of any violation contained
herein. Respondent’s entry into this Agreed Order shall not constitute a waiver
of any defense, legal or equitable, which Respondent may have in any future
administrative or judicial proceeding, except a proceeding to enforce this
order.
I. FINDINGS OF
FACT
1.
Complainant
is the Commissioner (“Complainant”) of the Indiana Department of Environmental
Management (“IDEM”), a department of the State of Indiana created by IC
13-13-1-1.
2.
Respondent
is Rea Magnet Wire Company, Inc. (“Respondent”), which owns and operate the
stationary magnet wire coating operation with Plant ID No. 157-00032, located
at 2800 Concord Road, in Lafayette, Tippecanoe County, Indiana (“Site”).
3.
IDEM has jurisdiction over the parties and the
subject matter of this action.
4.
Pursuant to IC 13-30-3-3, IDEM issued a Notice
of Violation (“NOV”) via Certified and Electronic Mail to:
Rea Magnet Wire Company, Inc. |
Business Filings, Inc. |
Attn: Jerry Long, CEO |
Registered Agent |
3400 E. Coliseum Blvd., Suite 200 |
Rea Magnet Wire Company, Inc. |
Fort Wayne, IN 46805 |
334 North Senate Avenue |
|
Indianapolis, IN 46204 |
|
(wkuslawdept@wolterskluwer.com) |
5.
During
an investigation including a records review conducted by a representative of
IDEM, the following violations were found:
a.
Pursuant
to Part 70 Permit 157-38828-00032, Condition
D.2.5(c), the oxidizer shall operate such that if the three-hour average temperature
falls below the setpoint temperature, corrective action shall be taken to
return the oxidizer to the setpoint temperature within 15 minutes. Corrective action must return the oxidizer to
the setpoint temperature not later than 30 minutes of the corrective action, or
the enamel flow to the oven shall be shut off.
On
May 7, 2018, the oxidizer for wire enameling oven 101-110 malfunctioned
resulting in the three-hour average temperature dropping below the setpoint
temperature, and enamel flow to the oven continued for 3 hours and 14 minutes,
in violation of Part 70 Permit 157-38828-00032, Condition
D.2.5(c).
b.
Pursuant
to Part 70 Permit 157-40037-00032, Condition
D.1.3(b), if the primary continuous monitoring system is not in operation, the
oxidizer temperature will be recorded using some manner of secondary system.
From November 25, 2018 to November
28, 2018, a serial communication loop affecting Ovens 421-424 and 425-428
failed twice resulting in the loss of the primary continuous monitoring system
for these ovens, and the oxidizer temperature was not recorded, in violation of
Part 70 Permit 157-40037-00032, Condition
D.1.3(b).
6.
Orders
of the Commissioner are subject to administrative review by the Office of
Environmental Adjudication under IC 4-21.5; however, in recognition of the settlement
reached, Respondent acknowledges notice
of this right and waives any right to administrative and judicial review of
this Agreed Order.
II. ORDER
1.
This Agreed Order shall be effective
(“Effective Date”) when it is approved by Complainant or Complainant’s delegate, and has been received by Respondent. This Agreed
Order shall have no force or effect until the Effective Date.
2.
Respondent shall comply with Part 70 Permit 157-40037-00032
unless superseded by a permit revision or renewal.
3.
All submittals required by this Agreed Order,
unless IDEM notifies the Respondent otherwise in writing, shall be sent to:
Andrew Taylor,
Enforcement Case Manager
Office of Air Quality
Indiana
Department of Environmental Management
100 North
Senate Avenue
Indianapolis,
IN 46204-2251
AKTaylor@idem.IN.gov
4.
Pursuant to IC 13-30-4-1, Respondent is
assessed and agrees to pay a civil penalty of Ten Thousand Two Hundred Dollars
($10,200). Said penalty amount shall be
due and payable to the Environmental Management Special Fund within thirty (30)
days of the Effective Date; the thirtieth day being the “Due Date.”
5.
Civil penalties are payable by check to the
“Environmental Management Special Fund.” Checks shall include the Case Number
of this action and shall be mailed to:
Indiana
Department of Environmental Management
Accounts
Receivable
IGCN, Room
1340
100 North
Senate Avenue
Indianapolis,
IN 46204
6.
In the event that the monies
due to IDEM pursuant to this Agreed Order are not paid on or before their Due
Date, Respondent shall pay interest on the unpaid balance at the rate
established by IC 24-4.6-1. The interest shall be computed as having accrued from
the Due Date until the date that Respondent pays any unpaid balance. Such interest
shall be payable to the Environmental Management Special Fund,
and shall be payable to IDEM in the manner specified in Paragraph 5,
above.
7.
Signatories to this Agreed Order certify that
they are fully authorized to execute this Agreed Order and legally bind the
party they represent.
8.
This Agreed Order shall apply to and be binding
upon Respondent and all successors and assigns. Respondent shall provide a copy
of this Agreed Order, if in force, to any subsequent owners, successors, or
assigns before ownership rights are transferred.
9.
No change in ownership, corporate, or
partnership status of Respondent shall in any way alter the Respondent’s status
or responsibilities under this Agreed Order.
10.
Respondent shall ensure that all contractors,
firms, and other persons performing work under this Agreed Order comply with
the terms of this Agreed Order.
11.
In the event that any terms of
this Agreed Order are found to be invalid, the remaining terms shall remain in
full force and effect and shall be construed and enforced as if this Agreed
Order did not contain the invalid terms.
12.
This Agreed Order is not and shall not be
interpreted to be a permit or a modification of an existing permit. This Agreed
Order, and IDEM’s review or approval of any submittal made by Respondent pursuant
to this Agreed Order, shall not in any way relieve Respondent of the obligation
to comply with the requirements of any applicable permits or any applicable
Federal or State laws or regulations.
13.
Complainant does not, by its approval of this
Agreed Order, warrant or aver in any manner that Respondent’s compliance with
any aspect of this Agreed Order will result in compliance with the provisions
of any permit, order, or any applicable Federal or State law or regulation.
Additionally, IDEM or anyone acting on its behalf shall not be held liable for
any costs or penalties Respondent may incur as a result of
Respondent’s efforts to comply with this Agreed Order.
14.
Nothing in this Agreed Order shall prevent or
limit IDEM’s rights to obtain penalties or injunctive relief under any
applicable Federal or State law or regulation, except that IDEM may not, and
hereby waives its right to, seek additional civil
penalties for the violations specified in the NOV.
15.
Nothing in this Agreed Order shall prevent IDEM
or anyone acting on its behalf from communicating with the U.S. Environmental
Protection Agency (“U.S. EPA”) or any other agency or entity about any matters
relating to this enforcement action. IDEM or anyone acting on its behalf shall
not be held liable for any costs or penalties Respondent may incur as a result of such communications with the U.S. EPA or any
other agency or entity.
16.
This Agreed Order shall remain in effect until
Respondent has complied with all terms and conditions of this Agreed Order and
IDEM has issued a Resolution of Case letter to Respondent.
TECHNICAL
RECOMMENDATION: |
|
RESPONDENT: |
|||||
Department
of Environmental Management |
|
Rea Magnet Wire Company, Inc. |
|||||
|
|
|
|||||
By: |
|
|
By: |
|
|||
|
David
P. McIver, Chief |
|
Printed: |
|
|||
|
Enforcement
Section |
|
Title: |
|
|||
|
Office
of Air Quality |
|
|
|
|||
Date: |
|
|
Date: |
|
|||
|
|
|
|
|
|||
|
|
|
|||||
COUNSEL
FOR COMPLAINANT: |
|
COUNSEL
FOR RESPONDENT: |
|||||
For
the Department of Environmental Management |
|
|
|||||
|
|
|
|||||
By: |
|
|
By: |
|
|||
|
|
|
|
|
|||
|
|
|
|
|
|||
Date: |
|
|
Date: |
|
|||
|
|
|
|
|
|||
APPROVED
AND ADOPTED BY THE INDIANA DEPARTMENT OF ENVIRONMENTAL |
|||||||
MANAGEMENT THIS |
|
DAY OF |
|
,
2021. |
|||
|
|||||||
|
For
the Commissioner: |
||||||
|
|
||||||
|
Signed
on May 26, 2021 |
||||||
|
Matthew
Stuckey |
||||||
|
Assistant
Commissioner |
||||||
|
Office
of Air Quality Indiana
Department of Environmental Management |
||||||