STATE OF
INDIANA |
) |
|
BEFORE THE
INDIANA DEPARTMENT |
||
|
|||||
COMMISSIONER
OF THE DEPARTMENT Complainant, v. ESSROC
CEMENT CORPORATION, Respondent. |
) |
|
|||
AGREED ORDER
Complainant
and Respondent desire to settle and compromise this action without hearing or
adjudication of any issue of fact or law, and consent to the entry of the
following Findings of Fact and Order.
Pursuant to IC 13-30-3-3, entry into the terms of this Agreed Order does
not constitute an admission of any violation contained herein. Respondent's entry into this Agreed Order
shall not constitute a waiver of any defense, legal or equitable, which
Respondent may have in any future administrative or judicial proceeding, except
a proceeding to enforce this order.
I. FINDINGS OF FACT
1.
Complainant
is the Commissioner (“Complainant”) of the Indiana Department of Environmental
Management (“IDEM”), a department of the State of Indiana created by Indiana
Code (“IC”) 13-13-1-1.
2.
Respondent
is Essroc Cement Corporation (“Respondent”), which
owns and operates the source with Plant ID No. 017-00005, located at 3084 West
County Road 225 South, in Logansport, Cass County, Indiana (“Site”).
3.
IDEM
has jurisdiction over the parties and the subject matter of this action.
4.
Pursuant
to IC 13-30-3-3, IDEM issued a Notice of Violation (“NOV”) via Certified Mail
to:
Francesco
Carantani, President |
CT
Corporation System, Registered Agent |
Essroc Cement Corporation |
150
West Market Street Suite 800 |
3251
Bath Pike |
Indianapolis,
IN 46204 |
Nazareth,
PA 18064 |
|
5.
Respondent
owns and operates a stationary Portland cement manufacturing source.
6.
During
an investigation conducted by a representative of IDEM, the following
violations were found:
a.
Pursuant
to 40 CFR 63.1220(a)(1) and Permit T017-26351-00005,
Administrative Amendment 017-32431-00005 Condition E.4.2(34), no source shall emit
dioxins/furans in excess of 0.40 ng TEQ/dscm
corrected to 7 percent oxygen, provided that the combustion gas temperature at
the inlet to the initial dry particulate matter control device is 400°F or
lower based on the average of the test run average temperatures.
Essroc Cement Corporation conducted a stack test on
Kiln #2 on October 24 – 25, 2014, with dioxins/furans emissions of 0.977 ng
TEQ/dscm corrected to 7 percent oxygen, in violation
of 40 CFR 63.1220(a)(1) and Permit T017-26351-00005, Administrative Amendment
017-32431-00005 Condition E.4.2(34).
b.
Pursuant
to 40 CFR 63.1220(a)(3) and Permit T017-26351-00005,
Administrative Amendment 017-32431-00005 Condition E.4.2(34), no source shall
emit semi-volatile metals in excess of 330 µgm/dscm,
combined emissions, corrected to 7 percent oxygen.
Essroc Cement Corporation conducted a stack
test on Kiln #2 on October 24 – 25, 2014, with semi-volatile metals combined
emissions of 671 µgm/dscm TEQ/dscm
corrected to 7 percent oxygen, in violation of 40 CFR 63.1220(a)(3) and Permit T017-26351-00005,
Administrative Amendment 017-32431-00005 Condition E.4.2(34).
7.
Respondent
received interim operating approval from IDEM via e-mails on February 27, 2015
to use operating parameter limits established in the January 23, 2015 NOC (from
the 2014 CPT) and OPLs consisting of lower kiln feed rate, lower ESP inlet
temperature, and lower SVM feed rate.
8.
Respondent
conducted a retest of Kiln #2 on June 18 - 19, 2015. The Notification of Compliance (NOC) is
pending.
9.
In
recognition of the settlement reached, Respondent waives any right to
administrative and judicial review of this Agreed Order.
II. ORDER
1.
This
Agreed Order shall be effective (“Effective Date”) when it is approved by
Complainant or Complainant’s delegate, and has been received by
Respondent. This Agreed Order shall have
no force or effect until the Effective Date.
2.
Respondent
shall comply with 40 CFR 63 Subpart EEE and Permit T017-26351-00005,
Administrative Amendment 017-32431-00005 Condition E.4.2(34).
3.
Respondent
shall comply with the interim approval granted on February 27, 2015 until
submittal of a Notification of Compliance in accordance with the interim
approval.
4.
All
submittals required by this Agreed Order, unless Respondent is notified
otherwise in writing by IDEM, shall be sent to:
Marty
Yeates, Compliance and Enforcement Manager |
Compliance
and Enforcement Branch – Mail Code 61-53 |
Indiana
Department of Environmental Management |
100
North Senate Avenue |
Indianapolis,
IN 46204-2251 |
5.
Respondent
is assessed and agrees to pay a civil penalty of Fifteen Thousand Seven Hundred
Fifty Dollars ($15,750.00). Said penalty
amount shall be due and payable to the Environmental Management Special Fund
within thirty (30) days of the Effective Date; the 30th day being
the “Due Date”.
6.
Civil
penalties are payable by check to the “Environmental Management Special Fund.” Checks shall include the Case Number of this
action and shall be mailed to:
IDEM Office
of Legal Counsel |
IGCN,
Rm N1307 |
100 N
Senate Ave |
Indianapolis,
IN 46204 |
7.
This
Agreed Order shall apply to and be binding upon Respondent and its successors
and assigns. Respondent’s signatories to this Agreed Order certify that they
are fully authorized to execute this Agreed Order and legally bind the party
they represent. No change in ownership,
corporate, or partnership status of Respondent shall in any way alter its status
or responsibilities under this Agreed Order.
8.
In
the event that the monies due to IDEM pursuant to this Agreed Order are not
paid on or before their Due Date, Respondent shall pay interest on the unpaid
balance at the rate established by IC 24-4.6-1.
The interest shall be computed as having accrued from the Due Date until
the date that Respondent pays any unpaid balance. Such interest shall be payable to the
Environmental Management Special Fund, and shall be payable to IDEM in the
manner specified in Paragraph 6, above.
9.
In
the event that any terms of this Agreed Order are found to be invalid, the
remaining terms shall remain in full force and effect and shall be construed
and enforced as if this Agreed Order did not contain the invalid terms.
10.
Respondent
shall provide a copy of this Agreed Order, if in force, to any subsequent
owners or successors before ownership rights are transferred. Respondent
shall ensure that all contractors, firms and other persons performing work
under this Agreed Order comply with the terms of this Agreed Order.
11.
This
Agreed Order is not and shall not be interpreted to be a permit or a
modification of an existing permit. This
Agreed Order, and IDEM’s review or approval of any submittal made by Respondent
pursuant to this Agreed Order, shall not in any way relieve Respondent of its
obligation to comply with the requirements of its applicable permit or any
applicable Federal or State law or regulation.
12.
Complainant
does not, by its approval of this Agreed Order, warrant or aver in any manner
that Respondent’s compliance with any aspect of this Agreed Order will result
in compliance with the provisions of any permit, order, or any applicable
Federal or State law or regulation.
Additionally, IDEM or anyone acting on its behalf shall not be held
liable for any costs or penalties Respondent may incur as a result of Respondent’s
efforts to comply with this Agreed Order.
13.
Nothing
in this Agreed Order shall prevent or limit IDEM’s rights to obtain penalties
or injunctive relief under any applicable Federal or State law or regulation,
except that IDEM may not, and hereby waives its right to, seek additional civil
penalties for the same violations specified in the NOV.
14.
Nothing
in this Agreed Order shall prevent IDEM or anyone acting on its behalf from
communicating with the EPA or any other agency or entity about any matters
relating to this enforcement action.
IDEM or anyone acting on its behalf shall not be held liable for any
costs or penalties Respondent may incur as a result of such communications with
the EPA or any other agency or entity.
15.
This
Agreed Order shall remain in effect until IDEM issues a Resolution of Case
letter to Respondent.
TECHNICAL
RECOMMENDATION: |
|
RESPONDENT: |
|||||
Department
of Environmental Management |
|
Essroc
Cement Corporation |
|||||
|
|
|
|||||
By: |
|
|
By: |
|
|||
|
Vaughn
Ison, Chief |
|
Printed: |
|
|||
|
Compliance
and Enforcement Section 3 |
|
Title: |
|
|||
|
Office
of Air Quality |
|
|
|
|||
Date: |
|
|
Date: |
|
|||
|
|
|
|
|
|||
|
|
|
|||||
|
|
COUNSEL
FOR RESPONDENT: |
|||||
|
|
|
|||||
|
|
|
|||||
|
|
|
By: |
|
|||
|
|
|
|
|
|||
|
|
|
|
|
|||
|
|
|
Date: |
|
|||
|
|
|
|
|
|||
APPROVED
AND ADOPTED BY THE INDIANA DEPARTMENT OF ENVIRONMENTAL |
|||||||
MANAGEMENT THIS |
|
DAY OF |
|
,
2015. |
|||
|
|||||||
|
For
the Commissioner |
||||||
|
|
||||||
|
Signed
on August 3, 2015 |
||||||
|
Keith
Baugues, Assistant Commissioner |
||||||
|
Office
of Air Quality |
||||||
|
Indiana
Department of Environmental Management |
||||||